Skip to main content

TKA with retained hardware guided by intraoperative ultrasonography – a case report

Abstract

Background

When a conservative management of gonarthrosis yields unsatisfactory results, a total knee arthroplasty (TKA) is recommended as an alternative approach. The implant survival is crucial for the long-term success of the procedure. However, in case of patients with retained hardware after past orthopedic procedures, providing correct alignment of the implant, which contributes to its longevity, is especially challenging. Here we present the use of an intra-operative ultrasonography for implant positioning in a 83-year-old male, undergoing TKA, without hardware removal, which was contraindicated due to his advanced age and comorbidities. Other imaging modalities taken into consideration are also described.

Case presentation

The right knee joint was approached with anterior incision. A femoral guide was introduced extramedullary. Ultrasonography was used to pinpoint the center of the femur’s head. Tibial’s guide was introduced intramedullary followed by a standard cut of the proximal part. Cemented ZIMMER NEXGEN prosthesis was used. Layered closure was applied. The placement of implant in neutral axis was confirmed on radiographs.

Conclusions

Our case demonstrates that ultrasonography might be helpful during TKA-procedure for implant positioning. However, more studies are needed to evaluate accuracy and application of ultrasound in the intraoperative settings.

Peer Review reports

Background

With increasing life expectancy incidence of osteoarthrosis rises – which is observed in developed, countries [1]. According to the American Academy of Orthopedic Surgeons and American College of Rheumatology guidelines, in initial management of gonarthrosis, various non-pharmacological (such as exercise, weight-loss and physiotherapy) and pharmacological interventions (including both nonsteroidal anti-inflammatory drugs and opioids) are used for symptom management [2, 3]. However, when conservative management of gonarthrosis does not provide sufficient pain relief - surgical interventions, such as arthroscopy, and joint replacement - total knee arthroplasty (TKA) - remains an alternative. In Poland more than 20.000 TKA procedures are performed each year. Success of the procedure relies on time of implant survival, for which correct alignment of implant is considered the most important factor. In order to improve the accuracy of implant’s components alignment, intra-medullar (IM) guides are routinely used [2]. However, in some circumstances – for instance in patients with retained hardware after previous surgery - their use might not be possible.

Pre-operative presence of retained hardware in the ipsilateral lower limb makes TKA particularly challenging. History of surgical interventions may influence local anatomical conditions, making placement of prosthetic material along the mechanical axis particularly difficult. Removal of hardware is usually advised, but it is linked with higher risk of complications such as periprosthetic fractures and poorer outcome [4]. Therefore, in presence of retained hardware, usage of various technical aids such as computer-assisted surgeries (CAS) and patient-specific blocks (PSP) have been described the most frequently [5]. As for today there were no cases of intra-operative ultrasonography use for the assessment of implant’s elements positioning described in the literature.

Case report

An 83 year-old man presented with a pain in the right knee of 8 in VAS (visual analogue scale). The symptoms were worsening over the last few years. He had a history of arterial hypertension, glaucoma and cataract. Forty years ago he had right femur fracture, and underwent surgical intervention. Plate and screws after osteosynthesis were not removed, and no documentation on the details of the intervention were available. He also underwent prostatectomy, appendectomy and hemorrhoidectomy in the past. The patient signed an informed consent for publishing his case.

On admission the patient was stable, BP 125/85 mmHg, HR 72/min. Initial laboratory results were within normal values. Pre-procedurally the patient was administered ananticoagulant according to local standards (enoxaparin, 40 mg) and a prophylactic dose of antibiotic (cefazoline) along with his regular drug regime. Based on the radiological features of right lower limb joints the patient was qualified for total knee arthroplasty with a cemented knee prosthesis - NexGen (LPS-Flex) implant (Fig. 1).

Fig. 1
figure 1

Ultrasound head placement to confirm extramedullary guide positioning

Due to long time interval between past surgery and current intervention and concomitant diseases, the patient was not found eligible for hardware removal. Extensive surgery including simultaneous hardware removal and TKA could put the patient at unacceptably high risk of complications (such as infection, perioperative fracture, and significant blood loss), because of his advanced age and comorbidities (Fig. 2).

Fig. 2
figure 2

Ultrasound image demonstrating placement of the guide along femoral shaft and bone

Placement of femoral guide intramedullary (which is preferred by most surgeons because, as it makes fitting of the prosthetic material easier, because the rod goes along anatomical axis of the limb) was not possible due to the presence of retained hardware. Its presence would not allow passage of intramedullary rod. Therefore, a decision to use an extramedullary guide was made preoperatively. Correct insertion of extramedullary guide is found challenging, because visual assessment of reference points used to determine the correct positioning is difficult intraoperatively. However, because confirmation of guide’s correct position is vital in order to achieve a good long-term outcome, ultrasound was chosen to inspect its position along the mechanical axis, being an accessible, inexpensive and a non-invasive imaging modality that could be performed intraoperatively by a trained member of the surgical team.

Several other imaging methods were considered. Fluoroscopy was not found to be optimal, because it requires a specific position of the limb (flexion in the hip and knee joint (of 90 degrees). It is also linked with an exposure to radiation, which forms its disadvantage in comparison with ultrasound. Using a patient specific instrument (PSI) was also not applicable to this case. It imposes performing an MRI of the limb, which was contraindicated. There was no available documentation of the previous surgery, therefore the metal alloy of the retained hardware was unknown.

TKA was performed in supine position. The right knee joint was approached with anterior incision. Numerous degenerative changes were present in both medial and lateral compartment, dominating in the medial compartment. Anterior compartment presented normally. Hardware retained after previous intervention, in the form of screws and an ostheosyntesis plate were present. After examining local conditions, a femoral guide was introduced extramedullary. Ultrasonography was used to pinpoint the center of the femur’s head. Distal cut in femur was performed. Tibial guide was than introduced intramedullary followed by a standard cut of the proximal part. The initial fit of implants was assessed. The patella’s osteophytes were removed. It was followed by ZIMMER NEXGEN prosthesis embedment on cement (vacuum mixed). Size of the tibial part was 5, femoral part F and polyethylene insertion – 9 mm. Layered closure was applied with the introduction of ATS reciprocal drainageto reduce oedema at the surgical site.

On the 2nd day after surgery the drainage was removed (it collected 200 ml of bloody excretion, which was within normal volumes expected after TKA). The postoperative period was uneventful. The correct position of the implants along the mechanical axis was confirmed on X-ray. On the 4th postoperative day the patient was able to walk using crutches and he was discharged from the hospital and he was advised to continue rehabilitation, use of analgesics (paracetamol 3x500mg, dexketoprofen 2x25mg taken as needed) and anticoagulant (enoxaparin 40 mg) administered daily in the first 6 weeks after discharge.

At a follow-up visit 6 months after surgery the patient was generally satisfied with the results of TKA, The patient recovered full range of motion (in comparison with the contralateral side). Pain decreased significantly to 1–2 in VAS (before surgery – up to 8 in VAS). On physical examination knee joint had normal appearance, with no signs of edema (Fig. 3).

Fig. 3
figure 3

Postoperative X-ray confirming prosthesis placement in the neutral axis

Discussion and conclusions

The most important factor to achieve patient’s satisfaction with TKA procedure for end-stage gonarthrosis is long-term quality of life improvement and pain reduction, which can be translated into correct placement of implant – within the neutral axis. However in only around 75% of TKA’s an ideal alignment is acheived [6].

Introduction of guides for implant’s positioning can be performed intramedullary or extramedullary. Intramedullary approach is associated with better stability and durability of implants, but it is also related with a higher risk of blood loss during procedure and post-operative complications (hypoxia, fracture, fat embolism, death) [7, 8]. However, intramedullary approach is not always feasible, as in the case described above.

In our experience, the greatest challenge for a surgeon performing TKA is the presence of retained hardware from previous lower limb procedures. It is a priori connected with an increase in the risk of postoperative complications [4]. Options that can be considered before performing TKA in such patients are (1) removing the hardware, (2) implementing computer-assisted surgery techniques or (3) using an extramedullary guide. (1) Removal of retained hardware enables use of intramedullary approach, but the surgery duration is longer and it bears the highest rate of side effects – up to 28% [9]. (2) Recently published paper confirms that computer-guided arthroplasty results in lower rate of complications, but long-term observational data does not prove its superiority over traditional technique [10, 11]. Therefore in this case, an extramedullary guide assisted by ultrasound was used to confirm implant’s correct positioning.

Imaging is a necessary step before the procedure, but it may also be used intra-procedurally to localize anatomic reference points to allow correct placement of the extramedullary guide. X-ray, computed tomography and magnetic resonance imaging are usually methods of choice. Matsuda et al. (2004) states that ultrasonography indicates center of the femoral head within 5 mm in 56% cases and within 10 mm in 89,5% cases. It appears to be highly reliable, noninvasive and easily accessible imaging modality [12]. Our case describes how ultrasonography might be implemented intraoperatively to assess implant’s placement during TKA-procedure in some settings, as in the case described above - a patient with unknown details of past interventions (such as material from which the hardware was made) and concomitant diseases, which were preventing surgical hardware removal before arthroplasty. However, its use might be limited because this requires presence of a member in the surgical team who is trained in its use. A randomized controlled trial assessing intraoperative use of ultrasound in TKA procedure could further evaluate the applications and accuracy of this imaging modality.

Availability of data and materials

The data that support the findings of this study are available from the corresponding author, W.K, upon reasonable request. The data are not publicly available, as it might compromise the confidentiality of patient whose case was described in the case report.

Abbreviations

ATS:

Autotransfusion system

CAS:

Computer-assisted surgery

IM:

Intra-medullar

PSI:

Patient specific instrument

PSP:

Patient-specific blocks

TKA:

Total knee arthroplasty

VAS:

Visual analogue scale

References

  1. Cross M, Smith E, Hoy D, et al. The global burden of hip and knee osteoarthritis: estimates from the global burden of disease 2010 study. Ann Rheum Dis. 2014;73:1323–30.

    Article  Google Scholar 

  2. Jevsevar DS, Brown GA, Jones DL, et al. The American Academy of Orthopaedic Surgeons evidence-based guideline on: treatment of osteoarthritis of the knee, 2nd edition. J Bone Joint Surg Am. 2013;95(20):1885–6.

    Article  Google Scholar 

  3. Hochber MC, Altman RD, April KT, et al. American College of Rheumatology 2012 recommendations for the use of nonpharmacologic and pharmacologic therapies in osteoarthritis of the hand, hip, and knee. Arthritis Care Res. 2012;64(4):465–74.

    Article  Google Scholar 

  4. Manrique J, Rasouli MR, Restrepo C, et al. Total knee arthroplasty in patients with retention of prior hardware material: what is the outcome? Arch bone Jt Surg. 2018;6:23–6.

    PubMed  PubMed Central  Google Scholar 

  5. Vaishya R, Vijay V, Agarwal AK. Total knee arthroplasty using patient-specific blocks after prior femoral fracture without hardware removal. Indian J Orthop. 2018;52:154–60.

    Article  Google Scholar 

  6. Haritinian EG, Pimpalnerkar AL. Computer assisted Total knee arthroplasty: does it make a difference? Maedica (Buchar). 2013;8:176–81.

    Google Scholar 

  7. Tang Q, Shang P, Zheng G, et al. Extramedullary versus intramedullary femoral alignment technique in total knee arthroplasty: a meta-analysis of randomized controlled trials. J Orthop Surg Res. 2017;12:1–7.

    Article  Google Scholar 

  8. Baldini A, Adravanti P. Less invasive TKA: extramedullary femoral reference without navigation. Clin Orthop Relat Res. 2008;466:2694–700.

    Article  Google Scholar 

  9. Kovar FM, Strasser E, Jaindl M, et al. Complications following implant removal in patients with proximal femur fractures - an observational study over 16years. Orthop Traumatol Surg Res. 2015;101:785–9.

    Article  CAS  Google Scholar 

  10. Brown MJ, Matthews JR, Bayers-Thering MT, et al. Low incidence of postoperative complications with navigated Total knee arthroplasty. J Arthroplast. 2017;32:2120–6.

    Article  Google Scholar 

  11. Ollivier M, Parratte S, Lino L, et al. No benefit of computer-assisted TKA. Clin Orthop Relat Res. 2018;476:126–34.

    Article  Google Scholar 

  12. Matsuda Y, Ishii Y, Ichimura K. Identifying the center of the femoral head using ultrasonography to assess the higher accuracy of femoral extramedullary guides in TKA. J Orthop Sci. 2004;9:6–9.

    Article  Google Scholar 

Download references

Acknowledgements

The authors would like to thank their colleagues from the Department of Orthopaedic Surgery, for their support and accurate comments that enriched this manuscript.

Funding

The authors declare that they have received no funding from any organization for this paper, including their employers.

Author information

Authors and Affiliations

Authors

Contributions

All authors participated in drafting the article. TP and KW revised it critically for important intellectual content, and provided the case description. MH performed literature search and wrote the introduction and discussion parts of the manuscript. All authors give final review and approval of the version to be submitted and any revised version.

Corresponding author

Correspondence to Konarski Wojciech.

Ethics declarations

Ethics approval and consent to participate

Written informed consent was obtained from the patient prior to the procedure.

Consent for publication

The patient whose case was described has signed an informed consent to publish his case, including all accompanying images prior to writing this manuscript.

Competing interests

The authors whose names are listed certify that they have no affiliations with or involvement in any organization or entity with any financial interest, or non-financial interest (such as personal or professional relationships, in the subject matter or materials discussed in this manuscript.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Poboży, T., Wojciech, K. & Hordowicz, M. TKA with retained hardware guided by intraoperative ultrasonography – a case report. BMC Surg 19, 126 (2019). https://0-doi-org.brum.beds.ac.uk/10.1186/s12893-019-0585-6

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/s12893-019-0585-6

Keywords