Skip to main content
  • Research article
  • Open access
  • Published:

Differences of tensile strength in knot tying technique between orthopaedic surgical instructors and trainees

Abstract

Background

Knot tying technique is an extremely important basic skill for all surgeons. Clinically, knot slippage or suture breakage will lead to wound complications. Although some previous studies described the knot-tying technique of medical students or trainees, little information had been reported on the knot-tying technique of instructors. The objective of the preset study was to assess surgeons’ manual knot tying techniques and to investigate the differences of tensile strength in knot tying technique between surgical instructors and trainees.

Methods

A total of 48 orthopaedic surgeons (postgraduate year: PGY 2–18) participated. Surgeons were requested to tie surgical knots manually using same suture material. They were divided into two groups based on each career; instructors and trainees. Although four open conventional knots with four throws were chosen and done with self-selected methods, knot tying practice to have the appropriate square knots was done as education only for trainees before the actual trial. The knots were placed over a 30 cm long custom made smooth polished surface with two cylindrical rods. All knots were tested for tensile strength using a tensiometer. The surgical loops were loaded until the knot slipped or the suture broke. The tensile strength of each individual knot was defined as the force (N) required to result in knot failure. Simultaneously, knot failure was evaluated based on knot slippage or suture rupture. In terms of tensile strength or knot failure, statistical comparison was performed between groups using two-tailed Mann–Whitney U test or Fisher exact probability test, respectively.

Results

Twenty-four instructors (PGY6–PGY18) and 24 trainees (PGY2–PGY5) were enrolled. Tensile strength was significantly greater in trainees (83.0 ± 27.7 N) than in instructors (49.9 ± 34.4 N, P = 0.0246). The ratio of slippage was significantly larger in instructors than in trainees (P < 0.001). Knot slippage (31.8 ± 17.7 N) was significantly worse than suture rupture (89.9 ± 22.2 N, P < 0.001) in tensile strength.

Conclusions

Mean tensile strength of knots done by trainees after practice was judged to be greater than that done by instructors in the present study. Clinically, knot slippage can lead to wound dehiscence, compared to suture rupture.

Peer Review reports

Background

Knot-tying technique is an extremely important basic skill for all orthopaedic surgeons [1,2,3]. Clinically, knot slippage or breakage will lead to wound complication such as dehiscence. For instance, in terms of knee replacement surgery, the suture tension in the proximal capsule showed a marked increase along with an increase in the knee flexion angle, and the maximum tension was 44 N based on a previous study [4]. However, knot strength varied widely (16–328 N) among expert surgeons [2]. Therefore, security of knot-tying is essential for all surgeries. According to previous studies, it has been a technically demanding task to obtain an appropriate security of knot-tying especially for young surgeons, as approximately 45% of trainees were unable to tie knots securely and about 15% of knots were judged as dangerous [5]. On the other hand, knot security had poor correlation with surgical experience and more important correlation with the differences in knot tying technique and type of knot created [6]. As a clinical education for trainees, instructors usually teach the way to perform an appropriate knot tying technique in the surgical field. However, no instructors really know how appropriate their own knots. Although some previous studies described the knot-tying technique of medical students or trainees after practice [1, 3, 5, 7, 8], little information had been reported on the difference of knot-tying technique between surgical instructors and trainees.

The main purpose of the present study was to assess surgeons’ manual knot tying techniques and to investigate the differences of tensile strength in knot-tying technique between surgical instructors and trainees. The second aim was to let surgical instructors and trainees know the accuracy of their own knots. It was hypothesized that knot strength would vary among all surgeons including surgical instructors and trainees, and there were no differences of knot-tying technique between surgical instructors and trained trainees.

Methods

A total of 48 surgeons (9 females and 39 males) participated in the present study. From May to July in 2019 and May to July in 2020, surgical instructors and trainees working at department of orthopaedic surgery in our hospital were invited to participate in the present study. Average career lifetime as a doctor was 6.7 years (postgraduate year: PGY 2–18). Surgeons with career lifetime greater than 20 years were excluded from the current study, as most of authors had career lifetime with longer than 20 years. Attending surgeons were provided with consent confirming their voluntary participation. Surgeons were divided into two groups based on each career; instructors and trainees. They were requested to tie surgical knots manually using same suture material including No. 1 PDS (Ethicon, Inc, Somerville, New Jersey). Four open conventional knots with four throws were chosen for the present investigation and done with self-selected methods for each surgeon. However, before the actual trial, knot tying practice to have the appropriate square knots was done as education only for trainees using textbook and/or string. The knots were placed over a 30 cm long custom made smooth polished surface with two cylindrical rods (Ethicon, Inc, Somerville, New Jersey) (Fig. 1). The rod was anchored firmly on both ends during knot tying. All knots were tested for tensile strength using a tensiometer (Digital force gauge, Nidec cooperation, Kyoto, Japan). The surgical loops of No.1 PDS were loaded until the knot either broke or slipped. The tensile strength of each individual knot was defined as the force (N) required to result in knot failure by slippage or rupture. Simultaneously, knot failure was evaluated based on knot slippage or suture rupture. This educational study was done using a verbal consent, which was approved by the Ethics Committee and Institutional Review Board of our university hospital (IRB No. 20190174). In our hospital, a written consent was not applicable regarding the educational study as any patients were not involved.

Fig. 1
figure 1

Tensile strength was measured using a portable tensiometer

In terms of tensile strength or knot failure, statistical comparison was performed between groups using two-tailed Mann–Whitney U test or Fisher exact probability test, respectively. All statistical analyses were done with the Microsoft Excel Statistical Package, version 2019 (Social Survey Research Information, Tokyo, Japan). Moreover, tensile strength was compared between suture rupture and knot slippage using two-tailed Mann–Whitney U test. In terms of gender difference, tensile strength was compared using two-tailed Mann–Whitney U test. Furthermore, Pearson's coefficient was used to analyze correlations between postgraduate year and tensile strength. The threshold for statistical significance was set at a P value of < 0.05.

Results

A total of 24 instructors (PGY6–18) and 24 trainees (PGY2–5) were enrolled in the present study. Subspecialties for instructors were spine (3 surgeons), tumor (2 surgeons), upper extremity (9 surgeons), and lower extremity (10 surgeons), whereas subspecialty was not available for trainees. Average careers as a doctor were 10.6 ± 3.7 years for instructors and 3.0 ± 0.6 years for trainees since they graduated from medical school or university (Table 1). Two females and 22 males were allocated in instructors, whereas 7 females and 17 males were in trainees. Mean tensile strengths were 77.3 ± 25.6 (N) for trainees and 54.0 ± 40.1 (N) for instructors. Knot strength varied widely (7–138 N) among surgeons. Interestingly, mean tensile strength was significantly greater in trainees than in instructors (P = 0.0246). Knot slippage was observed in 17 out of 24 instructors and 3 out of 24 trainees (Table 1). Similarly, the ratio of slippage was significantly larger in instructors than in trainees (P < 0.001). Concerning the knot failure, tensile strengths of suture rupture and knot slippage were 89.9 ± 22.2 (N) and 31.8 ± 17.7 (N), respectively. Knot slippage was significantly worse than suture rupture as to tensile strength (P < 0.001) (Fig. 2). Knot strengths in females and males were 71.4 ± 30.8 (N) and 64.1 ± 36.6 (N), respectively. There was not significantly different between female and male surgeons (P = 0.59). Tensile strength was negatively correlated with postgraduate year of surgeons (r = − 0.34; 95% confidence interval, − 0.56 to − 0.06, P = 0.02) (Fig. 3).

Table 1 Comparison of data between instructors and trainees (mean ± S.D.)
Fig. 2
figure 2

Tensile strengths of suture rupture and knot slippage

Fig. 3
figure 3

Relationship between postgraduate year and tensile strength

Discussion

The result of the present study supported our hypothesis that knot strength would vary among all surgeons including surgical instructors and trainees (7–138 N). The main finding of the present study was that knot-tying technique used by trainees after practice was judged to be superior to those used by instructors.

Batra et al. assessed the influence of surgeon's tying technique on knot security using 0 and 2–0 monofilament and multifilament nylon sutures with a portable tensiometer, and concluded that knot-tying technique used by medical students was judged to be superior to those used by surgeons after students had practice knot-tying to make four-throw square knots appropriately [7]. Similarly, from the present study, mean tensile strength was significantly greater in trainees than in instructors. Therefore, practice seemed to be essential both for trainees and instructors. In addition, trainees were usually taught regarding knot-tying technique during the actual surgery at the operating room and thus tended to perform the knot-tying carefully based on the instruction from the senior surgeons [6]. On the other hand, surgical instructors were confident with knot-tying technique and less prudent to make knots in the present simulation as they had rarely experienced major wound complications during the surgical procedures so far, while the true reason that some instructors could not make the appropriate knots was unknown. However, in this trial, three trainees could not make the secure knots even if the practice was done. This seemed to be a problem, and thus the education program should be continuous [9]. Ind et al. indicated that knot-tying workshops could improve the ability of trainees to tie reef knots [5]. In terms of knot strength, a previous cadaveric study suggested that the suture tension in the proximal capsule at the knee joint showed a marked increase along with an increase in the knee flexion angle and the maximum tension was 44 N [4]. Therefore, knot slippage can be risky for capsule dehiscence, as tensile strengths for slippage was 31.8 ± 17.7 (N) and the incidence of dangerous knots was high in the present study even if No. 1 PDS was used. Appropriate knot-tying method to avoid wound dehiscence is a fundamental technique even for surgical instructors as well as trainees.

Several limitations should be described. First, knot-tying methods could not be standardized in the present study, even if four-throw square knots were recommended for all surgeons. Therefore, it was unknown whether weaker knots were square or not. Second, it is unknown whether knot slippage will lead to the actual clinical complication such as postoperative bleeding or wound dehiscence. Third, only monofilament material including No. 1 PDS was used in the current investigation. Thus, the result may be different if a braided material is utilized. Lastly, although sample size calculation was done based on the initial 20 samples (10 in each group), sufficient power was not obtained as standard deviation was large in each group even if significant differences were obtained using data from 48 surgeons. However, the results of the present study offer useful information when considering the accuracy of knot-tying technique both in instructors and trained trainees.

Conclusion

Knot-tying technique used by trainees after practice was judged to be superior to those used by instructors in the present study. Clinically, knot slippage can be risky for wound dehiscence, compared to knot breakage.

Availability of data and materials

The datasets used and/or analysed during the current study available from the corresponding author on reasonable request.

Abbreviations

PGY:

Postgraduate year

References

  1. Franz DA, Batra EK, Morgan RF, Edlich RF. A portable tensiometer for assessing knot-tying technique. Orthopedics. 1995;18:555–8.

    CAS  PubMed  Google Scholar 

  2. Hanypsiak BT, DeLong JM, Simmons L, Lowe W, Burkhart S. Knot strength varies widely among expert arthroscopists. Am J Sports Med. 2014;42:1978–84.

    Article  Google Scholar 

  3. Gilmer BB, Guerrero DM, Coleman NW, Chamberlain AM, Warme WJ. Orthopaedic residents improve confidence and knot-tying speed with a skills course. Arthroscopy. 2015;31:1343-8.e2.

    Article  Google Scholar 

  4. Kiriyama Y, Matsumoto H, Toyama Y, Nagura T. A miniature tension sensor to measure surgical suture tension of deformable musculoskeletal tissues during joint motion. Proc Inst Mech Eng H. 2014;228:140–8.

    Article  Google Scholar 

  5. Ind TE, Shelton JC, Shepherd JH. Influence of training on reliability of surgical knots. BJOG Int J Obstet Gynaecol. 2001;108:1013–6.

    Article  CAS  Google Scholar 

  6. Ching SS, Mok CW, Koh YX, Tan SM, Tan YK. Assessment of surgical trainees’ quality of knot-tying. J Surg Educ. 2013;70:48–54.

    Article  Google Scholar 

  7. Batra EK, Taylor PT, Franz DA, Towler MA, Edlich RF. A portable tensiometer for assessing surgeon’s knot tying technique. Gynecol Oncol. 1993;48:114–8.

    Article  CAS  Google Scholar 

  8. Willis R, Erwin D, Adelaja F. Struggling prior to a teaching event results in superior short-term skills acquisition in novice learners. J Surg Educ. 2020;77:34–9.

    Article  Google Scholar 

  9. Huang E, Vaughn CJ, Chern H, O’Sullivan P, Kim E. An objective assessment tool for basic surgical knot-tying skills. J Surg Educ. 2015;72:572–6.

    Article  Google Scholar 

Download references

Acknowledgements

Not applicable.

Funding

This study was not supported.

Author information

Authors and Affiliations

Authors

Contributions

KH designed the study. KH, KK, YI, AM, YK, AO, NM, TS, RN, and SK accumulated the data. KH and MY coordinated and supervised data collection. KH and KK analyzed the data. KH drafted the manuscript. All authors (KH, MY, KK, YI, AM, YK, AO, NM, TS, RN, and SK) contributed to interpretation of the findings. All authors participated in reviewing and editing the manuscript. Keio OASIS is a name of our team. All authors contributed equally to this work. All authors read and approved the final manuscript.

Corresponding author

Correspondence to Mitsuru Yagi.

Ethics declarations

Ethics approval and consent to participate

This educational study was done using a verbal consent, which was approved by the Ethics Committee and Institutional Review Board of Keio University Hospital (IRB No. 20190174). In our hospital, a written consent was not applicable regarding the educational study as any patients were not involved.

Consent for publication

Not applicable.

Competing interests

The authors declare no conflict of interest.

Additional information

Publisher's Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Harato, K., Yagi, M., Kaneda, K. et al. Differences of tensile strength in knot tying technique between orthopaedic surgical instructors and trainees. BMC Surg 21, 75 (2021). https://0-doi-org.brum.beds.ac.uk/10.1186/s12893-021-01079-5

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/s12893-021-01079-5

Keywords